كلية الصيدلة
Permanent URI for this communityhttps://repository.neelain.edu.sd/handle/123456789/490
Browse
Item Evaluation of Microbial Contamination of cosmetics sold on a piece meal basis(Al-Neelain University, 2019-10) Abd Al rhaman Mahammod Al sheikhBackground: Due to economical problems in Sudan, some of the Sudanese cannot afford buying the intact container of the cosmetic, therefore they buy part of it, in non sterile containers using spatula or spoon which is not sterile and the removal of the part of the product is not done under aseptic condition, this is done so many times daily which may lead to the contamination and spoilage of original product, never the less they are stored in bad conditions. Aims: Enumeration, isolation and identification of microorganisms with ability to survive and develop in cosmetics. Method: The present study aims to investigate microbial contamination of 235 cosmetic products. The samples were collected randomly in different dosage forms which include creams, ointments and gels from different packaging designs which are wide mouth jars and collapsible tubes, they obtained from Boutiques, houses, and shops in Khartoum, Bahri, Omdurman and Al gazera in different storage temperatures. They were examined for microbial limit test which includes quantitative and qualitative limits. Results: Bacterial and fungal contamination was found in 152 samples (64%). The maximum bacterial counts were found in body creams compared to other tested cosmetic samples, followed by gels and ointments samples. The quantitative microbiological testes showed that (76.1%) were found to exceed bacteria count limit and (62.1%) were found to exceed fungal count limit while 56 (23.9%) and 89(37.1%) were found to be within bacterial and fungal limits in count, respectively. From the total number of 211 samples cream the results we found that, cream is highly contaminated with S.aureus (43.1%), E.coli(42.1%,), C.albicans(18%), Salmonella(6%), and absence of P.aeruginsa(0.0%). From the total number of 9 samples ointments the results we found that, ointments were highly contaminated with E.coli (33.3%), followed by C.albicans(11.1%), and absence of S.aureus, Salmonella and P.aeruginsa(0.0%). From the total number of 15 samples gel the results obtained that, gel is highly contaminated with E.coli(53.3%) S.aureus (33.3%), and C.albicans(40%), Salmonella(20%), and absence of P.aeruginsa(0.0%). regarding contamination in different storage temperature, the results showed a higher degree of contamination and abundance of contaminants bacteria in temperatures range from 28˚C-30˚C, and the fugal contamination at temperature 25˚C. Regarding packaging designs the results obtained in this study from wide mouth jar is highly contaminated with bacteria (78.1%), and fungi (74.1%), in comparison with collapsible tubes which represent bacterial contamination about (72.2%), and fungi (50.4%). The sensitivity of different contaminants was examined towards antimicrobial agents, and the results found that Co-trimoxazole, Quinolones (Ciprofloxacin, Levofloxacin) and Meropenem were the most active drugs as they were effective against all isolates (100%). All examined isolates recovered from cosmetics products were resistant to Penicillins. All isolates of S.aureus were Vancomycin resistant. Furthermore, all isolates of Salmonella spp, S,auerous and (90%) of E.coli was resistant to macrolides. Conclusions: it had been been found that high incidence of bacterial and fungal contamination by potential hazardous microorganisms. Recommendations: From health point of view the cosmetic products should be free from any pathogenic microorganisms and the degree of contamination should be within the limits stated by the pharmacopeia. Selling cosmetics on a piecemeal basis should be prohibited to prevent contamination and to assure efficacy and safety of such products. The products are not on their original containers and without label and stored in bad conditions. To overcome this problem the products can be produced in a sachets dosage form. الخلفية: بسبب المشاكل الاقتصادية في السودان, بعض السودانيين لا يستطيعون تحمل شراء العبوات الكاملة لمستحضرات التجميل, وبالتالي تباع علي اساس التجزئه في حاويات غير معقمة باستخدام ملعقة غير معقمة. المنتج لا يباع في ظل ظروف منع التلوث, ويتم ذلك كثيرا خلال اليوم والذي قد يؤدي الي تلوث المستحضرالاصلي والجزء الذي يباع منة الي افراد مختلفين. الهدف:معرفة درجة التلوث وعزل الميكروبات التي تعيش في مستحضرات التجميل التي تباع علي اساس مجزأ(قدر ظروفك). الطريقة : تهدف الدراسة الحالية الي دراسة التلوث الجرثومي ل235 منتجا تجميليا. تم جمع العينات عشوائيا باشكال صيدلانية مختلفة تشمل الكريمات , المراهم والهلام من تصميمات مختلفة التغليف وهي عبارة وعاء واسع الفوهه وانابيب قابلة للطي, تم الحصول عليها من البوتيكات , مراكز الاتصالات والمنازل في الخرطوم, بحري, ام درمان والجزيرة في دراجات حرارة تخزين مختلفة. النتائج : وجد تلوث بكتيري وفطري في 152 عينة (64%). تم العثور علي اكبر عدد من البكتريا في الكريمات التجميلية التي تم اختبارها, تليها عينات الهلام والمراهم. اظهرت الاختبارات المايكروبولجية الكمية ان(76.1%) تجاوزت حد العد البكتيري و(62.1%) وجد انها تتجاوز حد العد الفطري في حين ان 56(23.9%) و89(37.1%) وجدت ضمن حدود البكتريا والفطريات في العد, علي التوالي.من اجمالي عدد211 عينة من الكريمات, وجد ان الكريمات ملوثة بشدة بالبكتريا المكورات العنقودية الذهبيه (43.1%), يلية الاشريكية القولونية (42.1%), يلية المبيضة البيضاء (18%), يلية السالمونيلا(6%), وغياب الزائفة الزنجارية (0.0%). من اجمالي عدد 9 عينات من المراهم, وجد ان المراهم ملوثة بدرجة عالية من الاشريكية القولونية (33.3%), يليه المبيضة البيضاء (11.1%), وغياب البكتريا المكورات العنقودية الذهبيه,السالمونيلا, و الزائفة الزنجارية (0.0%). من اجمالي عدد 15 عينة من الهلام, وجدنا الهلام ملوث بشدة الاشريكية القولونية (53.3%), المكورات العنقودية الذهبيه (33.3%), , يلية المبيضة البيضاء (40%), يلية السالمونيلا(20%), وغياب الزائفة الزنجارية (0.0%). كما هو الحال بالنسبة للتلوث في درجة حرارة التخزين المختلفة, اظهرت النتائج وجود اعلي درجة من التلوث ووفرة البكتريا الملوثة في درجات الحرارة من 28 درجة مئوية الي 30 درجة مئوية, ودرجة حرارة الفطر25 درجة مئوية. فيما يتعلق بتصميمات التغليف النتائج التي تم الحصول عليها في هذه الدراسة ان الوعاء ذو فتحة واسعة ملوث بشدة بالبكتيريا(78.1%), والفطريات(74.1%), مقارنة مع الانابيب القابلة للطي التي تمثل تلوث البكتريا حوالي(72.2%), والفطريات (50.4%). الاستنتاجات : وجود نسبة عالية من التلوث البكتيري والفطري من الكائنات الحية الدقيقة الخطرة. التوصيات : من الناحية الصحية يجب ان تكون مستحضرات التجميل خالية من ىاي كائنات مجهرية ممرضة ويجب ان تكون درجة التلوث ضمن الحدود الذي يحددها دستور الادوية. ينبقي حظرالمستحضرات التي تباع علي اساس التجزئة لمنع التلوث وضمان فعالية وسلامة هذة المنتجات. كما ان هذه المستحضرات ليس بها ملصق يوضح المكونات وتاريخ الانتاج وانتهاء الصلاحية والاستعمال, للتغلب علي هذه المشكلة يمكن انتاج هذة المستحضرات في حاويات تحتوي كل منها علي جرعة واحدة او تنتج في عبوات صغيره اقل تكلفة.